Ethiopian Airlines Crash/ B737MAX grounding

ZiabR · 05-04-2019 08:33AM

Turbulent Bill wrote: »

Agreed, Boeing and Airbus form a duopoly and it's in both of their interests to keep this going. Airbus took a financial hit on the A380, same for Boeing on the MAX, but overall I wouldn't see either being seriously damaged long term.

I don't see it that way. the A380 is the best aircraft I have flown on hands down. It is a very safe and very comfortable flight. The issue was that is was to big and not economical to run with its 4 engines.

That is a considerable difference when compared to the MAX that has already had 2 catastrophic failures resulting in loss of life. The MAX is Boeing's best selling aircraft in the history of the company. It has over 5000 on order.

There is a big difference between an aircraft that is to big and surplus to requirements and an aircraft that falls out of the sky due to design oversights. Remember the only reason Boeing had to design the MCAS system in the first place is because they tried to save money, by not redesigning the 737 and instead bolt bigger engines onto the MAX and moving them forward. We already know that due to these 2 changes, the MAX had the tendency to go nose up.

Stimpyone · 05-04-2019 08:58AM

jasper100 wrote: »

= manufacturer at fault. Which contradicts your earlier "guess" that it leaves manufacturer off the hook to some degree.

It won't

Hmm. I'm not sure but I think you've misunderstood me.

If you read my comment again I was having a go at the reporting in the media more so than anything else.

Hence the "keep my powder dry" comment. That usually indicates that you reserve judgement until you have all the facts.

At no point did I put it forward as my "guess" as you put it and in fact I was responding to a previous posters point.

But hey ho....

ChikiChiki · 05-04-2019 10:48AM

The only solution to reinstill passenger confidence for this is to redesign the aircraft so that it flys straight and level without the need for software input. But Boeing wont take that option as it would come at heavy costs. Personally knowing what I know about MCAS I would not be confident getting on one with the software fix in place.

Muilenburgs statement certainly didnt help either. Its a huge mess.

Hotblack Desiato · 05-04-2019 11:19AM

GM228 wrote: »

Their book is full with build and delivery time estimates most likely based (at the time) on the assumption the A380 production and assembly lines could be still open

They were only producing 380s at a slow rate anyway, so I wouldn't expect large gains there. Suits them actually to not speed up delivieries too much, a full order book for years to come is money in the bank.

GM228 wrote: »

That very much depends on the airline and the scale of their operations, look at AA, yes they are huge compared to the average airline, but up to a few years ago they were near 100% Boeing, in the last number of years they have become 51% Boeing and 43% Airbus (the rest being Embraer and MD).

They'd still save money running one of 737/320 instead of both. Interesting though that Ryanair are now kind of running a mixed fleet (Laudamotion) so they now have first hand experience of the economics of a 320 operation. More ammunition for them to drive hard bargains with Boeing...

GM228 · 05-04-2019 02:19PM

Hotblack Desiato wrote: »

They were only producing 380s at a slow rate anyway, so I wouldn't expect large gains there. Suits them actually to not speed up delivieries too much, a full order book for years to come is money in the bank.

That may be the case, but, it's an airframe which is a lot slower to build and assemble than say an A320neo, and there is a massive workforce and facilities solely dedicated to it which will become available in time and no doubt speed up production of other airframes, but as you say it probably suits to stick with current production rates.

Hotblack Desiato wrote: »

Interesting though that Ryanair are now kind of running a mixed fleet (Laudamotion) so they now have first hand experience of the economics of a 320 operation. More ammunition for them to drive hard bargains with Boeing...

I don't think Lauda (as it's called now) counts as Ryanair running a mixed fleet, Lauda is still a separate airline with Ryanair Holdings as the parent company.

The Ryanair we know (as in the airline company Ryanair DAC) is not the parent company of Lauda, rather it's Ryanair Holdings (Ryanair PLC), who are also the holding company for Ryanair.

Muahahaha · 05-04-2019 03:41PM

Muahahaha wrote: »

There were reports in some media yesterday that the pilots turned off the MCAS but somehow it turned itself back on which sounds bizarre. Did the report bear this out and if it did happen does it make this crash unique, i.e. a software system crashing a plane not because of failure to operate but instead operating when it had been commanded not to

Anyone know the answer to this? The NY Times are reporting that the pilots followed all the correct emergency procedures and ended up switching off the power to the MCAS entirely but even then it still continued on forcing the nose down. Like how could that even happen? They also reported that at the last minute the pilots switched the MCAS back on and it was at that point the nose did one final massive tilt downwards and from there there was no way of saving it.

If the above is true and the pilots did everything right and disabled the MCAS then are we now into unchartered territory? It is one thing for only one AoA sensor to be connected to MCAS, another thing for the sensor to be giving faulty data but on an entirely different level when software that was over ruled by a human continues to operate despite being switched off and that software literally goes on to crash the plane. Astounding stuff if true, we seem to be into the realm of robots killing humans.

05-04-2019 03:49PM

Humans killing humans. Heads should roll for how that was implemented.

Imagine a Tesla ignoring driver attempts at overriding its self-driving system.

GM228 · 05-04-2019 04:36PM

Boeing CEO Dennis A Muilenburg saying sorry on behalf of Boeing:-

With the release of the preliminary report.....it's apparent that in both flights the MCAS activated in response to erroneous AOT information

Whilst well suspected and pretty much confirmed at this stage, is this the first official acknowledgement by Boeing themselves that the apparent issue was MCAS?

https://twitter.com/BoeingCEO/status/1113880952575549441?s=19

Royale with Cheese · 05-04-2019 05:38PM

Relentlessly focused on safety... yet were desperate to keep these things from being grounded when the Ethiopian flight went down, and this is after they'd been working on a fix for months for the known MCAS issue since the Lion air crash.

This whole debacle makes my blood boil. A cut and dry case of profit above all else, in an industry where that just can't be allowed to happen.

cnocbui · 05-04-2019 06:09PM

GM228 wrote: »

Boeing CEO Dennis A Muilenburg saying sorry on behalf of Boeing:-

Whilst well suspected and pretty much confirmed at this stage, is this the first official acknowledgement by Boeing themselves that the apparent issue was MCAS?

https://twitter.com/BoeingCEO/status/1113880952575549441?s=19

No, I'd say the software update would be an admission.

RiseToMe · 06-04-2019 05:03AM

Boeing has announced it is slowing production of the 737 MAX to concentrate on fixing the software:

http://news.sky.com/story/boeing-making-progress-on-737-max-software-update-11685354

murphaph · 06-04-2019 06:34AM

I won't be flying on one for at least a couple of years regardless of what the now discredited FAA says. The only data to trust will be the statistics which at present do not look at all good for this airplane.

The Boeing apology was barely that too.

Henry Ford III · 06-04-2019 07:49AM

GM228 wrote:

Boeing CEO Dennis A Muilenburg saying sorry on behalf of Boeing:-

Hands up it's our fault and we will fix it.

The trouble is that hundreds of innocent people are dead, and no fix will bring them back.

ZX7R · 06-04-2019 08:20AM

Silly question time,
If the problem is resolved with a program update,and plane is safe to fly.
Can they rename the plane like change the max part of the name so people won't be afraid to fly on them.

What happens if it can't be fixed and turns out to be a fundamental design flaw of air frame or something major.

Henry Ford III · 06-04-2019 09:14AM

Yes of course they could rename and relaunch it. People aren't stupid though.

If it's not inherently safe you'd hope it never gets certification to fly.

smurfjed · 06-04-2019 09:18AM

Is there any attention being given to the failures of the AOA sensors? For the Lion Air crash, I understand that the sensor failed on the previous flight and was replaced, so why did the 2nd new sensor immediately fail?

As for the Addis crash, there is talk that the sensor was damaged by a bird strike, is there anything official to support that?

DublinDilbert · 06-04-2019 10:07AM

smurfjed wrote: »

Is there any attention being given to the failures of the AOA sensors? For the Lion Air crash, I understand that the sensor failed on the previous flight and was replaced, so why did the 2nd new sensor immediately fail?

As for the Addis crash, there is talk that the sensor was damaged by a bird strike, is there anything official to support that?

From what i've seen about the Lion air crash is that there was no indication to the pilots that the angle of attack sensor was reading erroneous information when on taxi and on take off roll.

Does anyone know the min speed at which the AOA sensor should operate reliably at?

Its hard to believe there's no sanity checks on such an important input. I guess its something that can't be checked statically after maintenance, do they just verify its free to rotate without restriction?

cnocbui · 06-04-2019 11:39AM

RiseToMe wrote: »

Boeing has announced it is slowing production of the 737 MAX to concentrate on fixing the software:

http://news.sky.com/story/boeing-making-progress-on-737-max-software-update-11685354

More lies from Boeing. There is no way their riveters and machinists have been drafted in to write software.

jasper100 · 06-04-2019 12:31PM

cnocbui wrote: »

More lies from Boeing. There is no way their riveters and machinists have been drafted in to write software.

Where did they say they are?

Bob24 · 06-04-2019 01:36PM

jasper100 wrote: »

Where did they say they are?

I think the OPs point is that Boeing “slowing production of the 737 MAX so it can focus its attention on fixing the flight-control software” seems like a bit of a strange inference; as slowing production is unlikely to free up many ressources which would help solving software issues.

cnocbui · 06-04-2019 01:44PM

jasper100 wrote: »

Where did they say they are?

They didn't say it, but what they said was illogical nonsense. They said they were slowing production while they concentrate on software. Can you explain to me why you would have to do that - the connection between the two? In what way does slowing the mechanical task of physically making aircraft bodies, improve their capacity to write the software?

My son is a software developer. If I were to say I wasn't going to mow the lawn this weekend so that he could increase his output of lines of code you ought to say WTF?, because there is no logical connection between the activities.

What I am trying to get at is there must be some reason why they are slowing production, but since that function has no bearing on software development, why? Are they perhaps thinking the 'software' fix isn't going to be enough and that they will have to make actual changes to the aircraft?

Bob24 · 06-04-2019 01:55PM

cnocbui wrote: »

What I am trying to get at is there must be some reason why they are slowing production, but since that function has no bearing on software development, why? Are they perhaps thinking the 'software' fix isn't going to be enough and that they will have to make actual changes to the aircraft?

Agree there must be another reason, although it’s hard to know what it is without internal knowledge.

Could be what you said, could be that they know the fix will take much longer than anticipated and since they can’t deliver airplanes to airlines in the meantime there is no point building them to then have to store them for a prolonged period at their own cost, could even be that some airlines have cancelled orders or put them on hold and the production pipeline is shrinking.

Jeff2 · 06-04-2019 02:26PM

I'd say airlines have asked that the two optional extras are fitted to all of their plains ordered.

The disagree light will be fitted to all plains now as standard.

Bob24 · 06-04-2019 03:14PM

Jeff2 wrote: »

I'd say airlines have asked that the two optional extras are fitted to all of their plains ordered.

The disagree light will be fitted to all plains now as standard.

Boeing has already announced this would be the case, and that it would be retrofitted to all planes which are already in service at no extra cost for the airline.

As far as I understand it’s basically just a small software update to always show the information on the cockpit displays whereby before the software was only displaying if the airline had purchased a certain extra package (i.e. it was an artificial software restriction but the planes are technically all capable of displaying the info already) . So I assume it is already done in the latest beta software and will simply be enabled for all planes whenever the MCAS software update is being rolled out.

billy few mates · 06-04-2019 04:02PM

You can't just stop a production line when it's in full swing. Managing the flow of logistics is a science that's planned to the minute, a lot of the materials are either already on dock or in transit to the factory. It's probably more sensible to keep the production line in full flow and plan for a gradual wind down if the fix wasn't immediate. Of course the corollary of that is the storage problem for the completed air frames once they're actually completed.
Once the fix has been properly certified and tested it will be relatively straightforward to implement, once they're back in the air and the news cycle has been replaced the operators come looking for them again...

Blut2 · 06-04-2019 04:21PM

Slowing the production line down is a big step. I think it points to the required fix here being bigger, and taking a lot longer, than Boeing are letting on.

I doubt the slowdown its because of cancellations though, just because the order book is so large. I'd wager its that they don't want large numbers of airplanes building up to be stored at their own cost while this "fix" process drags on.

Irish Steve · 06-04-2019 05:05PM

The more that comes out of the woodwork on this, the less chance I see of a quick fix, given that the original fix was done for all the wrong reasons.

The FAA are very much also on the rack over this situation, and I am beginning to wonder if the end result of this mess will be that the 737Max will end up being redesignated as (for lack of a better model number) a 738, and for what are apparently good reasons, the type rating and training will have to be different from the 737 family.

If it happens, part of that rebrand will also mean massive changes to the whole concept of MCAS, and it may even result in Boeing having to make hardware changes to the airframe to overcome the problems that are inherent in the existing Max structure, to reduce or eliminate the problems that MCAS was supposed to fix.

I wonder if the whole concept of MCAS is now so discredited that there is no fix to it that will be acceptable to the industry or the regulators, and if that is the case, Boeing have a much bigger problem than just slowing down the production line for a while, we can only guess at the behind the scenes discussions that are happening with the larger customers like Southwest and Ryanair, who are going to be very worried about how they are going to manage this issue going forward, and how they will reassure their customers that the aircraft is safe.

A change of this magnitude will raise howls of protest from the beancounters in the airlines, and cause all manner of problems for Boeing during the transition, and has the potential to disrupt airline schedules for a long time, but the nature and depth of this problem seems to be such that there is no easy or quick fix that will overcome the very real issues that are now out in the open.

cnocbui · 06-04-2019 05:22PM

I predict Boeing shares will tank more than 5% on Monday when the market opens.

Jacovs · 06-04-2019 06:38PM

Bob24 wrote: »

Boeing has already announced this would be the case, and that it would be retrofitted to all planes which are already in service at no extra cost for the airline.

Wonder if they are also refunding those airlines who chose to pay for the optional extra on the already operational aircraft.

Noxegon · 06-04-2019 06:41PM

I’m honestly surprised that Ryanair hasn’t used this situation to save a lot of money on their MAX order. Though maybe they too are going for the wait and see approach.

Ethiopian Airlines Crash/ B737MAX grounding

Comments