Advertisement
If you have a new account but are having problems posting or verifying your account, please email us on hello@boards.ie for help. Thanks :)
Hello all! Please ensure that you are posting a new thread or question in the appropriate forum. The Feedback forum is overwhelmed with questions that are having to be moved elsewhere. If you need help to verify your account contact hello@boards.ie
Please note that it is not permitted to have referral links posted in your signature. Keep these links contained in the appropriate forum. Thank you.

https://www.boards.ie/discussion/2055940817/signature-rules
Hi there,
There is an issue with role permissions that is being worked on at the moment.
If you are having trouble with access or permissions on regional forums please post here to get access: https://www.boards.ie/discussion/2058365403/you-do-not-have-permission-for-that#latest

Audi A4 05 1.9tdi Question

  • 01-03-2014 12:25pm
    #1
    .223 Paul
    Registered Users, Registered Users 2 Posts: 26 ✭


    Hi Guys

    Iv just purchased an Audi A4 1.9tdi. Everything seems to be grand except for one thing. I noticed that the temperature gauge sits at around 70 (at the 10 o clock mark) Is this normal or should it rise to half way?

    Any suggestions or information would be greatly appreciated.

    Regards


Comments

  • #2
    biko
    Registered Users, Registered Users 2 Posts: 81,220 ✭✭✭✭biko


    Does the needle act erratically or just don't reach halfway?
    If the temp gauge doesn't reach halfway point it is probably the thermostat stuck open.
    If needle moves about then it's the coolant sensor.


  • #3
    .223 Paul
    Registered Users, Registered Users 2 Posts: 26 ✭.223 Paul


    Hi

    The thermostat just sits below the half way mark. the first degree is 50, the second is 70 and the middle mark is 90..mine just sits at the 70 mark? Is this bad do you think?

    thnaks


  • #4
    Harcrid
    Registered Users, Registered Users 2 Posts: 1,310 ✭✭✭Harcrid


    As Biko has said it is most likely a thermostat stuck open. Do you have any problem getting heat from the heater in the car? One of the possible symptoms of a stuck thermostat is the heater does not get very warm.


  • #5
    Needles73
    Registered Users, Registered Users 2 Posts: 599 ✭✭✭Needles73


    It's almost certain to be your thermostat. It's a very common problem. My a4 was the same. An easy enough fix. Better to get thermostat from dealer and the plastic housing it fits into. It's quite easy to break or damage the housing on removal as it's got two plastic pins which lock onto thermostat.


  • #6
    debabyjesus
    Registered Users, Registered Users 2 Posts: 774 ✭✭✭debabyjesus


    It should sit at 90 and stay there once warmed up. Sounds like stat cant close fully. It's easy change. Just two allen head 6mm? bolts holding the black supply pipe to the block. Take the pipe out the way and the stat will probably need a poke to free it from the block. Remove it and put the new one in asap to minimise coolant loss.

    Bolt the pipe back on and take the cap off the coolant reservoir and run the engine up to temp, turn on the heater fan in the cabin full whack and for a further 15 mins or so. That should be enough to bleed out any air.

    Let the engine go back cold for a few hours and then check coolant level and top up or whatever.

    Get your stat from dealer. Cheap enough maybe €30.

    It'll pay for itself in improved fuel economy fairly fast!


  • Advertisement
Advertisement